Place the fan up inside the housing and then line up the blower motor. allow blower motor assembly to drop down as low as it will go and then squeeze your hand in thru opening and put cage back on shaft. the tricky part is getting the hex nut started. thread it on with a couple of your fingers and then use a 1/4" ratchet to sneak up in opening and tighten.
Full Answer
What are some of the 2002 Buick LeSabre blower motor problems?
The blower motor in a 2002 Buick LeSabre provides the force to move hot and cold air through the vehicle's ventilation system. As this motor ages, the bearings inside it can wear out, causing a high-pitched whine or vibration that is audible from inside the passenger cabin.
Where can I get a replacement blower motor for a Buick?
Replacement blower motors are available from automotive parts stores, automotive salvage yards and Buick dealerships. Shift the Buick's transmission into park and turn off the engine.
How do you replace a blower motor on a Toyota Camry?
Remove the three 8 mm nuts holding the blower motor assembly into the dashboard HVAC unit, use a 1/4-inch ratchet and an 8 mm socket. Remove the blower motor's electrical connector and discard the old blower motor. Install the new blower motor in the HVAC cavity and replace the 8 mm mounting nuts.
Why does my blower motor make a high pitched noise?
As this motor ages, the bearings inside it can wear out, causing a high-pitched whine or vibration that is audible from inside the passenger cabin. Replacement blower motors are available from automotive parts stores, automotive salvage yards and Buick dealerships.
Where is the blower motor on a 2002 Buick LeSabre?
0:298:04How To Replace A Blower Motor On A Buick - YouTubeYouTubeStart of suggested clipEnd of suggested clipLike this and you pry it down and out if you don't have that you can just use a pair of needle noseMoreLike this and you pry it down and out if you don't have that you can just use a pair of needle nose pliers you grip it right here. And you pull down and slowly pull it out.
How much is a blower motor for a 2002 Buick LeSabre?
We currently carry 7 Blower Motor products to choose from for your 2002 Buick LeSabre, and our inventory prices range from as little as $91.99 up to $249.29. On top of low prices, Advance Auto Parts offers 5 different trusted brands of Blower Motor products for the 2002 Buick LeSabre.
Where is the blower fan motor located?
The blower motor is usually under the dashboard on the passenger side. Blower motors that make loud squeaks or rattling noises may be worn out and on the verge of packing it in, but sometimes those noises are caused by leaves or other debris that can be cleaned out after the motor is removed from the vehicle.
What can cause a blower motor to stop working?
In most cases, a blower motor resistor fails due to corrosion or overheating. Sometimes, the mechanical resistance to the motor rotation causes an excessive electric current that can overheat and prematurely damage the blower motor resistor.
How much is a blower motor for a Buick LeSabre?
Buick LeSabre Blower Motor Replacement Cost Estimate. The average cost for a Buick LeSabre blower motor replacement is between $399 and $429. Labor costs are estimated between $114 and $144 while parts are priced at $285.
Is it hard to replace a blower motor?
If you don't want to sweat or shiver, then find a good mechanic. The replacement of the blower motor is common and straightforward, so most shops will perform the repair — many on the same day.
How long does it take to change a blower motor?
It generally takes about 4 hours for an experienced technician to do a blower motor replacement. If you are doing it on your own in your garage with common tools, you can expect the job to take 6 hours or more.
How do you tell if it's the blower motor or resistor is bad?
A common symptom of a faulty blower motor resistor is a blower motor that is stuck on one setting. The blower motor resistor is the component directly responsible for controlling the blower motor fan speed. If the resistor shorts or fails, it may cause the blower motor to remain stuck on one fan speed.
Where is the blower motor reset button?
Locate the reset button on the furnace and press it to reset the furnace. It is usually located inside the blower compartment on the side of the blower motor. Be cautious as the housing may be hot. If the button is popped up, press it down.
How do you diagnose a blower motor problem?
How to Test a Blower MotorUse voltmeter or ohmmeter to check for a blown fuse. If you find one, replace it.Start car and see if blower motor works. ... If the circuits are in good repair but the blower motor keeps blowing fuses, replace the blower motor [source: You Fix Cars].