Exhaust manifolds cost an average of $500, while downpipes and mufflers cost between $50 to $150 each. Your exact costs depend on the make/model of your car and the extent of the damage. There are more costs associated with installing an exhaust system.
Full Answer
How much should I pay for a new muffler?
The cost of mufflers can range from $160 to $240 depending on what needs to be replaced and how much labor is associated with it. Some muffler repairs will require fixing broken clamps as well. If you think you have exhaust problems, you should go get a free inspection. The longer you wait, the worse your problems will get.
How much does it cost to repair/replace a muffler?
The good thing about a damaged muffler is that unless it's completely blown out, a repair is likely possible. If you do need to have it replaced, expect to spend between $150 to $300. The exact amount depends on the make and model of your car, the type of muffler you replace it with, and whether or not any extra parts need replacing as well.
What is estimated cost to replace the muffler?
- 2006 Mercedes-Benz S600: $2,836
- 2016 BMW 650i XDrive Gran Coupe: $1,109
- 2002 Isuzu Axiom: $373
- 2016 Volkswagen Passat: $589
- 2005 Mercedes-Benz ML500: $1,131
- 2002 Land Rover Freelander: $513
- Chrysler 300M: $423 to $1,094
- Mercury Mountaineer: $316 to $418
- Jaguar XFR: $1,553 to $1,567
- GMC G1500: $215 to $227
How much does it cost to install a new muffler?
Muffler replacement costs can range from $75 to $750 depending on several factors. The average cost for installing a mid-range replacement muffler on a typical sedan is between $150 and $250, including parts and labor. While inexpensive generic aftermarket mufflers are priced from $25 to $50, installing them can be difficult.
How much does it cost to replace a muffler and tailpipe?
If you do need to have it replaced, expect to spend between $150 to $300. The exact amount depends on the make and model of your car, the type of muffler you replace it with, and whether or not any extra parts need replacing as well.
How much does it cost to replace entire exhaust system?
between $300 and $1200You could be wondering. The cost of an exhaust system varies anywhere between $300 and $1200 depending on whether it's a complete system, type of exhaust system, and parts of the exhaust system. This is only the scratch on the surface.
How long does it take to replace a muffler and exhaust?
The simplest muffler replacement takes 30-60 minutes depending on your vehicle. Allow another hour or two if the mid-pipe or downpipe also needs service. These pipes can be difficult to reach, and may need to be replaced along with your muffler.
How much does it cost to put a new muffler on?
The Best in Auto Repair The average cost for exhaust muffler replacement is between $73 and $91. Labor costs are estimated between $70 and $88 while parts are priced at $3. This range does not include taxes and fees, and does not factor in your specific vehicle or unique location. Related repairs may also be needed.
Is exhaust worth replacing?
By improving the airflow through the system and decreasing back pressure, aftermarket exhausts reduce the energy wasted in the system having to overcome these pressure problems. This leads to better fuel efficiency. Better sound: Aftermarket mufflers can significantly louden the sound of your engine.
Is it worth replacing exhaust on old car?
Most cars do not need any exhaust work for upwards of 8–10 years due to the corrosion resistant, stainless steel used in exhaust systems installed in the factory. However, repairs will become more common and more expensive as components age and develop holes and leaks or when they fail completely.
Can I drive with a broken muffler?
The Toxic Exhaust The possibility of toxic exhaust fumes leaking into your car's ventilation system represents the largest reason for not driving with a broken or damaged muffler. You put yourself and others in serious - and potentially fatal - danger if this occurs while you drive.
Can I replace a muffler myself?
You can take your car to a muffler shop for a replacement, but installing a new muffler yourself is fairly easily and cost-efficient. To complete your muffler installation, you'll need a jack to lift up your car, a wrench, different sized ratchets, lubricant, and possibly a hacksaw.
How often should a muffler be replaced?
approximately five to seven yearsIn most U.S. vehicles, mufflers last approximately five to seven years. However, several factors such as frequent exposure to salt on roads, speed bumps, and potholes can result in premature aging.
How much does it cost to replace a muffler?
On average, though, you can expect a muffler replacement cost to range between $160 and $240 including parts and labor.
What factors affect the cost of mufflers?
Below are some key factors to consider: The year, make, and model of your vehicle – some cars have parts which are costlier to replace.
Why does my muffler fail?
Additional Components. Because the muffler is connected to the rest of your car’s exhaust system, it can sometimes fail or be damaged in conjunction with other exhaust components. Addressing these issues alongside the muffler replacement can quickly drive up the price of the service.
What is a muffler?
It sits between the catalytic converter and the exhaust pipe. Mufflers consist of a series of resonating chambers which muff le the noise produced by the engine.
How much does a catalytic converter cost?
Catalytic converters vary wildly in price depending on the make and model of your car – you could pay anything from $240 to over $1,000. Installing the converter is likely to cost an additional $100. Muffler. As mentioned earlier, the muffler helps to reduce the noise emitted by a car’s engine.
Why is exhaust system important?
The exhaust system is vital to your car’s overall functionality, so keeping it in good condition is essential. A properly functioning exhaust system not only reduces the amount of harmful emissions your vehicle releases; it also contributes to better fuel efficiency, and makes it quieter to run.
When was the muffler invented?
The muffler has a surprisingly long history – first patented back in 1897 by Milton and Marshall Reeves. Throughout the twentieth century and beyond, then, mufflers have made driving a much more comfortable experience for passengers, pedestrians, and car owners alike.
How much does it cost to replace a muffler?
The average cost for installing a mid-range replacement muffler on a typical sedan is between $150 and $250, including parts and labor. While inexpensive generic aftermarket mufflers are priced from $25 to $50, installing them can be difficult.
How long do mufflers last?
While mufflers last 10 years on average, the service life can range from five to 15 years depending on various factors, such as exposure to rain, snow and salt. Unfortunately, an inferior-grade aftermarket replacement muffler may only last three years in areas with harsh weather and driving conditions.
Why is my exhaust rusting?
Extensive exhaust problems can be caused by a damaged muffler if it isn’t replaced. If it is significantly rusted, the rust has probably made it’s way up the exhaust pipe. Mufflers can be difficult to replace the muffler alone on older cars because they are often welded in several places to the exhaust system.
Why is exhaust important?
The exhaust system plays an important role in diverting fumes from the engine, which in turn keeps the vehicle running smoothly. Accumulated exhaust gases can eventually cause engine deterioration. As a result, it is essential that you have your exhaust inspected regularly by a professional muffler shop.
What factors affect the cost of a car?
Factors That Affect the Cost. Year, make and model of your vehicle. Whether you replace it yourself, use an independent shop or go to a dealership (which is typically the most expensive option) Whether you use generic aftermarket parts or an OEM muffler, which is usually more expensive.
Who invented the muffler?
A prolific inventor, Milton Reeves designed the first muffler in 1897 to reduce the release of noise and toxic fumes. This component is typically mounted underneath and at the rear of a vehicle. Every state has laws governing the condition and performance of mufflers installed on everyday consumer vehicles.
Does a muffler come with a lifetime warranty?
Depending on the brand and quality, the muffler will come with a limited or a lifetime warranty. However, this usually does not cover the pipes and components attached to it that typically wear out faster than the muffler. For some vehicles, the muffler has to be ordered from a dealership if it is a “dealer only item”.
How much does it cost to replace an exhaust muffler?
The average cost for an Exhaust Muffler Replacement is between $811 and $829 but can vary from car to car.
What happens when a muffler breaks?
When the muffler has become sufficiently corroded it will no longer muffle the exhaust noise properly. The muffler brackets or rubber hangers can also break, allowing it to swing underneath the vehicle and hit the undercarriage.
How does a muffler work?
The muffler uses several sound deadening chambers that absorb vibrations as the exhaust gas passes through this forced maze. After passing through multiple chambers and baffles, the exhaust noise is quieted down to the designed level.
Why do mufflers fail?
The number one cause of muffler failure is corrosion from road salt or other debris. Collisions can also damage mufflers when the vehicle is rear ended. There is no recommended replacement interval for mufflers, and they often last the life of the vehicle.
What is the last step in exhaust gas?
The muffler is the last step for exhaust gas on the way out of the exhaust system. Mufflers reduce the noise created by exhaust gases emitted from the engine to make sure the vehicle drives quietly.
What is exhaust pipe?
What is an Exhaust Pipe? As the engine burns fuel to mechanical power, the liquid fuel is turned into a gaseous state full of toxic chemicals.
What happens when a part of the exhaust pipe fails?
When a portion of the exhaust pipe fails you may notice a check engine light, depending on which section has become perforated, but you will certainly notice the engine has become substantially louder and may lack power or use excessive amounts of fuel.
How does an exhaust pipe work?
The exhaust pipe works like any other pipe, as it channels exhaust gas from one place to the next. It begins at the exhaust manifold flange, moves down to a specialty pipe called a 'flex pipe', and from there a new portion of the exhaust pipe extends from the flex pipe to the catalytic converter.
Why is my exhaust pipe perforated?
If one portion of the exhaust pipe is perforated due to corrosion , it is likely that another location will soon have the same issue. having the entire exhaust system inspected for corrosion and damage can prevent a return trip to the shop in the near future. Also, the rubber and metal brackets used to secure the exhaust to the vehicle should be inspected, as the exhaust system is fairly heavy and will encourage corrosion to create perforations if not secured properly.
Bad Muffler Symptoms
There are always signs to look out for in a failing muffler. When you can know what is wrong with your vehicle in time, you will be able to save yourself some stress and time. Instead of completely replacing a part like in this case, the muffler you can repair and save yourself some cash.
Muffler Leak Repair Cost
A muffler leak if not taken proper care of can damage your engine. A leaking muffler can result in a burned exhaust valve which will, in turn, result in exhaust fumes from the combustion chambers flowing in the wrong way.
Catalytic Converter Replacement
The catalytic converter is a part of the automobile exhaust system. It does the work of converting harmful compounds in exhaust fumes into harmless compounds. A typical vehicle has its catalytic converter looking like a muffler in terms of shape.
Final Words
Now that you know what to expect and what to look out for when your vehicle muffler is starting to get bad. Early detection could save you the stress of getting a replacement and minor muffler repairs might just be all that is needed.
What Does an Exhaust System Do?
The exhaust system works to remove exhaust from the combustion reaction away from your engine. These systems involve one or more exhaust pipes and various components to reduce pollution and noise.
Exhaust System Install Cost
The average car owner can expect to pay around $800 to replace a car’s exhaust system. The typical range of prices is from $400 to $1,200. These costs include the parts and labor.
OEM vs Aftermarket Parts
When shopping for car parts, you have a choice between original equipment manufacturer (OEM) parts and aftermarket parts. OEM parts are made from the original manufacturer for specific makes/models. Aftermarket parts are made by third-party manufacturers who may or may not have the approval of the original manufacturer.
Factors that Affect the Cost of Installing an Exhaust System
Make/model. Like most car repairs, the costs depend on the make and model of your car. Some car brands require OEM exhaust systems while others have more compatibility with aftermarket products. Generally speaking, luxury brands are harder to repair than consumer brands.
Signs of a Broken Exhaust System
The most obvious sign of a broken exhaust system is overly loud engine noises. Sputtering and roaring could mean that your gaskets, muffler, or exhaust manifold are broken and are not absorbing noise.
Conclusions
Exhaust systems are a crucial part of your car and keep your engine in good working condition. Exhaust system installation sits in the middle of the price spectrum compared to other kinds of car repairs, with an average cost of around $800.
How much does it cost to replace flex pipe on a 2009 Chevy Traverse?
For a 2009 Chevrolet Traverse with a 3.6-liter engine. The labor time to replace the flex pipe is estimated at 1.2 hours. A factory replacement part is about $477, and a Walker replacement part is about $141.
What happens when a flex pipe fails?
The flex pipe usually fails by breaking internally, which then, causes an exhaust leak and noise. Depending on how the system is laid out, if the O2 sensors are placed downstream from the flex pipe, there may be fault codes set and running problems in the event of a failure.
Why is a flex pipe needed?
The flex pipe is necessary to allow the forward and backward rocking of a car engine on starting and acceleration. Usually, the flex pipe is a short section of exhaust made from a flexible accordion pipe and protected with a braided wire covering. A flex pipe allows a little more freedom in exhaust system design and a little better noise ...
What is the purpose of a flex pipe?
The primary purpose of a flex pipe is to absorb the rotational movements of a transverse engine under starting and accelerating forces. If an exhaust flex pipe needs replaced, the main additional part that might be of concern is one that can be a cause of flex pipe failure: the engine mounts.
How many mounts does an engine have?
An engine will usually have one or two engine mounts that specifically limit rotational forces, and if they are worn and allow too much movement that can cause the flex pipe to fail. The engine mounts should be inspected and replaced as necessary in conjunction with a flex pipe failure.
Can exhaust be modified?
Emission regulations often apply. Depending on exact laws and local regulations, sometimes, the exhaust system can’t be modified in any way, which would require a shop to install a certified replacement part and disallow any universal parts. The above flex pipe repair cost estimates are for certified parts.
Is there a maintenance interval for exhaust flex pipe?
There is no maintenance interval, and actual failures of an exhaust flex pipe are pretty rare, depending on what part of the country the vehicle is operated in. The primary enemy of an exhaust system is road salt.